The header image for SMC

Hand Built Quality

Fully carpeted internal structure fitted using High Temperature resistant adhesives

Water resistant Knauf Cavity Insulation – Providing excellent insulation and soundproofing. With resistance to condensation.

12 & 240 Volt Internal electric’s All our wiring is correctly weighted and fitted inside flexible conduit to minimise the chances of a short circuit. The internal power is handled through a Power Management System, which offers full Earth Leakage protection and fusing for both 240v and 12v systems. In addition it allows for charging of the large 110 Leisure battery or if needed the vans own battery.

Custom fitted bonded floor - fitted with Bus grade Taraplus flooring providing excellent grip even when wet.

Reimo TUV Approved Elevating Roofs and Strengthening Frame – we only fit elevating roofs and their accompanying strengthening frames that have passed European TUV regulations. Manufactured in Germany by Reimo

Vohringer Light Weight Laminated Furniture Boards – we only use the very best light weight German manufactured Vohringer 15mm thick plywood which is hot bond laminated on both sides. With a 15mm centre the furniture has excellent rigidity and the super hard Egger laminate finish will not succumb to the knocks of a campervan life. Far superior to any paper or vinyl finished product, your vehicle furniture will still look new after years of use and being half the weight of standard plywood you’ll also be carrying around half the load.

Hand Cut Furniture Every conversion is individual done to ensure a perfect panel fit between the furniture and the vans structure. None of our furniture is mass-produced outside of our workshop and then bolted in. We believe the only way to achieve an accurate finish is to treat each van individually. In addition all our cupboard doors (except gas locker door) fit flush with the face of the panel. This finish is much harder to achieve than the standard approach favoured by most converters.

Rear Bed Seats – for rear travel seats we fit fully crashed tested seats With full three point integral inertia seat belts as standard, we secure the seats to the floor of every vehicle to the manufacturer’s specification.

We also fit Rock & Roll type bed systems with a Memory Foam mattress.

Roof bed system - our in house designed roof bed system is fully carpeted, edged and features telescopic gas struts to lift it out of the way when not in use. It can also be easily removed if only two berths are required.

SMEV Sink Hob Combination unit – All our conversions feature this stylish sink/hob unit which is fitted with smoked glass lids. Water is provided and wasted into two internal tanks with the fresh tank incorporating an electric pump.

WAECO 12v Compressor Fridge Freezer - We favour the use of the WAECO 39ltr 12v Compressor Fridge. This requires no external venting and receives its power from the leisure battery, which is constantly charged by the engine or from the PMS charger when hooked up to a 240 supply.

Body Colour Keyed Bumpers – all our vans feature body colour keyed bumpers and smart modern vehicle graphics.

Vented Gas Locker & Leak Detection Alarms

Housing a 7 kg Gas Bottle with interchangeable tail featuring quick release connection & 30mb Caravan Regulator regulator. The locker has a sealed door and is vented through the floor - ensuring no gas leak will ever make its way into the living area of the vehicle. The locker is large enough to carry a 7kg cylinder. In addition for added peace of mind our conversion also include hard wired LPG & CO gas detection alarm system.

All installations are carried out by a fully trained and certified Caravan Gas Installer.